Propane Stove
INSTRUCTIONS FOR USE
U.S. and other Patents Pending
© 2004 The Coleman Company, Inc.
Model 5453 Series
IMPORTANT
Read this manual carefully before assembling, using or servic-
ing these stoves. Keep this manual for future reference. If you
have questions about assembly, operation, servicing or repair
of these stoves, please call Coleman at 1-800-835-3278 or
TDD: 316-832-8707. In Canada call 1-800-387-6161.
CERTIFIED
®
®
ANSI Z21.72b-CSA 11.2b (2002) Camp Stove
General Safety Information
cont.
DANGER
DANGER
• EXPLOSION - FIRE HAZARD
• Never store propane near high heat, open flames, pilot lights, direct
sunlight, other ignition sources or where temperatures exceed 120
degrees F (49°C).
DANGER indicates an imminently hazardous situation which, if not
avoided, will result in death or serious injury.
• Propane is heavier than air and can accumulate in low places. If you
smell gas, leave the area immediately.
• Never install or remove propane tank while outdoor stove is lighted,
near flame, pilot lights, other ignition sources or while outdoor stove is
hot to touch.
WARNING
WARNING indicates a potentially hazardous situation which, if not
avoided, could result in death or serious injury.
• During operation, this product can be a source of ignition. Never use
the stove in spaces that contain or may contain volatile or airborne com-
bustibles, or products such as gasoline, solvents, paint thinner, dust parti-
cles or unknown chemicals. Minimum clearances from combustible mate-
rials: 12 inches from the sides & 48 inches from the top.
• Provide adequate clearances around air openings into the combustion
chamber.
CAUTION
CAUTION indicates a potentially hazardous situation which, if not
avoided, may result in minor or moderate personal injury, or property
damage.
WARNING
DANGER
Not for home or recreational vehicle use.
We cannot foresee every use which may be made of our products.
Check with your local fire safety authority if you have questions
about use.
Failure to comply with the precautions and instructions provided with
these stoves can result in death, serious bodily injury and property loss or
damage from hazards of fire, explosion, burn, asphyxiation, and/or carbon
monoxide poisoning.
Other standards govern the use of fuel gases and heat producing prod-
ucts for specific uses. Your local authorities can advise you about these.
Only persons who can understand and follow the instructions should use
or service these stoves.
• Never refill disposable cylinders.
• Use the preset regulator that came with the stove. Do not attempt
to adjust.
If you need assistance or information such as an instruction manual or
labels, contact the Coleman Co., Inc.
3
General Safety Information
cont.
CALIFORNIA PROPOSITION 65:
DANGER
WARNING: This fuel, and byproducts of combustion of this fuel,
contain chemicals known to the state of California to cause cancer,
birth defects, or other reproductive harm.
• CARBON MONOXIDE HAZARD
WARNING
• This stove is a combustion appliance. All combustion appliances produce
carbon monoxide (CO) during the combustion process. This product is
designed to produce extremely minute, non-hazardous amounts of CO if
used and maintained in accordance with all warnings and instructions. Do
not block air flow into or out of the stove.
• BURN HAZARD
• Never leave stove unattended when hot or in use.
• Keep out of reach of children.
• Carbon Monoxide (CO) poisoning produces flu-like symtoms, watery eyes,
headaches, dizziness, fatigue and possibly death. You can’t see it and you
can’t smell it. It’s an invisible killer. If these symptoms are present during
operation of this product get fresh air immediately!
• For outdoor use only.
• Never use inside house, camper, tent, vehicle or other unventilated or
enclosed areas. This stove consumes air (oxygen). Do not use in unven-
tilated or enclosed areas to avoid endangering your life.
CAUTION
• SERVICE SAFETY
• Keep all connections and fittings clean. Inspect propane cylinder and
stove propane connections for damage before attaching.
• During set up, check all connections and fittings for leaks using
soapy water. Never use a flame. Bubbles indicate a leak. Check that
the connection is not cross-threaded and that it is tight. Perform anoth-
er leak check. If there is still a leak, remove the cylinder and contact
Coleman for service or repairs.
WARNING
• This product is fueled by propane gas. Propane gas is invisible, odorless,
and flammable. An odorant is normally added to help detect leaks and can
be described as a “rotten egg” smell. The odorant can fade over time so
leaking gas is not always detectable by smell alone.
• Use as a cooking appliance only. Never alter in any way or use with
any device or part not expressly approved by Coleman.
• Clean stove frequently to avoid grease accumulation and possible
grease fires.
• Propane gas is heavier than air and leaking propane will sink to the lowest
level possible. It can ignite by ignition sources including matches, lighters,
sparks or open flames of any kind many feet away from the original leak.
Use only propane gas set up for vapor withdrawal.
• Propane gas should be stored or used in compliance with local ordinances
and codes or with ANSI/NFPA 58. Turn off propane when not in use.
4
To Set Up
■ Close burner valve firmly.
DANGER
CAUTION
• SERVICE SAFETY
• Keep all connections and fittings
clean. Inspect propane cylinder and
stove propane connections for
damage before attaching.
• CARBON MONOXIDE HAZARD
•
•
For outdoor use only.
Never use inside house, camper, tent, vehicle or other unventilated or
enclosed areas. This stove consumes air (oxygen). Do not use in unventilated
or enclosed areas to avoid endangering your life.
• During set up, check all connections
and fittings for leaks using soapy
water. Bubbles indicate a leak. Never
use a flame.
Note: Use Coleman 16.4 oz disposable propane cylinders. The LP-gas
cylinder(s) used with stoves must be constructed and marked in accor-
dance with the specififcations for LP-gas cylinders of the U.S. Department
of Transportation or Transport Canada, CAN/CSA B339.
■ Remove plastic cap from top of
propane cylinder and screw
propane cylinder into regulator
hand tight.
■ Screw regulator into stove hand
tight.
5
To Light
■ Hold lighted match near burner
and open burner valve.
■ Adjust flame with burner valve.
■ Flame should be blue with hint
of yellow on tips.
DANGER
• EXPLOSION - FIRE HAZARD
• Propane is heavier than air and can accumulate in low places. If you smell
gas, leave the area immediately.
• Always attach or detach propane source outdoors; never while stove is lighted,
near flame, pilot lights, other ignition sources or while stove is hot to touch.
• This stove is red hot during use and can ignite flammables too close to the
burners. Keep flammables at least 12 inches from the sides and 48 inches from
the top of the stove. Keep gasoline and other flammable liquids and vapors well
away from stove.
WARNING
To Turn Off
• BURN HAZARD
•
•
Never leave stove unattended when hot or in use.
Keep out of reach of children.
■ Close burner valve firmly.
6
To Clean
To Store
■ Remove propane cylinder from
regulator and replace plastic cap
on cylinder.
■ Wipe clean with soft cloth and
mild household cleaner. Do not
use abrasives.
DANGER
• EXPLOSION - FIRE HAZARD
•
Never store propane near high
heat, open flames, pilot lights, direct
sunlight, other ignition sources or
where temperatures exceed 120
degrees F (49°C).
•
Refillable propane tanks must
always be stored outdoors in a well
ventilated space. Never store
propane tank in an enclosed area
(house, garage, etc.). If stove is to
be stored indoors, disconnect the
propane tank for outdoor storage.
■ Unscrew regulator from stove.
7
Things You Should Know
Parts List
1. It is unsafe and illegal in some places to store or use propane cylinders
of greater than 1.14 kg (2.5 lbs) water capacity (approximately 1 lb.
propane) in occupied enclosures.
2. The usual storage areas for camping and picnic equipment are the
basement, attic, or garage. To avoid the accumulation of dust, cobwebs,
etc., that is common in these areas, place your stove in a plastic bag and
seal it with a rubber band.
3. For repair service call one of the numbers on the front cover for location
of your nearest Coleman Service Center. If a service center is not conve-
niently located, attach to the product a tag that includes your name,
address, daytime telephone number and description of the problem.
Carefully package the product and send either by UPS or Parcel Post
insured with shipping and insurance prepaid to:
No.
Part Number Description
1
5453-2351
5453-1351
5430-5651
5453-3351
5453-1001
Grate
Knob
2
3
4
5
Regulator Assembly
Foot Assembly
Carry Case (Model 5453-741 only)
5
For products purchased in the United States:
The Coleman Company, Inc.
3600 North Hydraulic
Wichita, KS 67219
1
For products purchased in Canada:
Sunbeam Corporation (Canada) Limited
5975 Falbourne Street
3
Mississauga, Ontario
2
Canada L5R 3V8
4. If not completely satisfied with the performance of this product, please
call one of the numbers listed on the cover of this manual.
4
8
Warranty
Limited Lifetime Warranty
HOW TO OBTAIN WARRANTY SERVICE
The Coleman Company, Inc. (“Coleman”) warrants that for the period that you
own this product, it will be free from defects in material and workmanship.
Coleman, at its option, will repair or replace this product or any component of
the product found to be defective during the warranty period. Replacement will
be made with a new or remanufactured product or component. If the product is
no longer available, replacement may be made with a similar product of equal
or greater value. This is your exclusive warranty.
Take the product to an authorized Coleman service center.You can find the
nearest authorized Coleman service center by calling 1-800-835-3278 or TDD
316-832-8707 in the United States or 1 800 387-6161 in Canada. If a service
center is not conveniently located, attach to the product a tag that includes your
name, address, daytime telephone number and description of the problem.
Include a copy of the original sales receipt. Carefully package the product and
send either by UPS or Parcel Post insured with shipping and insurance pre-
paid to:
This warranty is valid for the original retail purchaser from the date of initial
retail purchase and is not transferable. Keep the original sales receipt. Proof of
purchase is required to obtain warranty performance. Coleman dealers, service
centers, or retail stores selling Coleman products do not have the right to alter,
modify or in any way change the terms and conditions of this warranty.
This warranty does not cover normal wear of parts or damage resulting from
any of the following: negligent use or misuse of the product, use on improper
voltage or current, use contrary to the operating instructions, disassembly,
repair or alteration by anyone other than Coleman or an authorized service
center. Further, the warranty does not cover Acts of God, such as fire, flood,
hurricanes and tornadoes.
Coleman shall not be liable for any incidental or consequential damages
caused by the breach of any express or implied warranty or conditions. Except
to the extent prohibited by applicable law, any implied warranty of merchantabil-
ity or fitness for a particular purpose is limited in duration to the duration of the
above warranty or conditions. Some states, provinces or jurisdictions do not
allow the exclusion or limitation of incidental or consequential damages or limi-
tations on how long an implied warranty lasts, so the above limitations or exclu-
sion may not apply to you. This warranty gives you specific legal rights, and you
may also have other rights that vary from state to state or province to province.
For products purchased in the United States:
The Coleman Company, Inc.
3600 North Hydraulic
Wichita, KS 67219
For products purchased in Canada:
Sunbeam Corporation (Canada) Limited
5975 Falbourne Street
Mississauga, Ontario
Canada L5R 3V8
Do not mail products with fuel in tanks, or with disposable propane
cylinders.
DO NOT RETURN THIS PRODUCT TO THE PLACE OF PURCHASE.
If you have any questions regarding this warranty please call
1-800-835-3278 or TDD 316-832-8707 in the United States or
1 800 387-6161 in Canada.
9
Notes:
10
|